LO 5-3895-271-12
NOTES:
1. FOR
OPERATION
OF
EQUIPMENT
IN
7. TRANSMISSION.
Check level each 50 hours.
Change gear lubricant only when required by
PROTRACTED COLD TEMPERATURES BELOW -15F
(-26C).
Remove lubricants prescribed in Key for
other foreign material.
After refill, operate for five
temperatures above -15F (-26C). Relubricate with
minutes, check for leaks and bring oil to "FULL" mark.
lubricants specified in Key for temperatures below -15 F
(-26C).
If OEA lubricant is required to meet the
8. HYDRAULIC TANK STRAINER. Each 100 h urs,
o
temperature ranges prescribed in the Key, OEA lubricant
remove tank cover plate, remove strainer, clean and
is to be used in place of OE/HDO-10 lubricant for all
reinstall strainer. After replacement, operate hydraulic
temperature ranges where OE/HDO-10 is specified in
system for 5 minutes, check for leaks, check oil level and
bring to "FULL" mark.
2. OIL CAN POINTS. Each 50 ho urs, lubricate all
9. LUBRICANTS. The following is a list of lubricants
clutch, brake, governor, steering linkage, yoke pins, ball
with military symbols and applicable specification
and socket joints, pivot pins, door hinges and fasteners,
numbers.
control linkages and all exposed adjusting threads with
OE/HDO. Each 1000 hours or with overhaul, lubricate
OE/HDO
MIL-L-2104
all oil impregnated bushings with OE/HDO.
GO
MIL-L-2105
GAA
MIL-G-10924
3. ENGINE OIL LEVEL HOT OR COLD CHECK. Cold
OEA
MIL-B-46176
engine, oil level should be at high mark on dipstick. Hot
BFS
MIL-L-46167
engine, oil level must be between high and low marks on
CW
FED-VV-L-751
dipstick (allow to set 5 minutes before checking).
(SD), Type II
P-D-680
4. ENGINE. Oil is to be changed each 100 hours.
Drain when lubricant is warm.
Copy of this Lubrication Order will remain with the
equipment at all times, instructions contained herein are
5. ENGINE OIL FILTER. Each 100 hours, remove filter
mandatory.
element, clean housing and install new filter element.
After installing new filter element, fill crankcase, operate
By order of the Secretary of the Army:
engine for 5 minutes, check housing for leaks, check
crankcase oil level and bring to "FULL" mark.
JOHN A. WICKHAM, JR.
General, United States Army
6. AIR CLEANER. Each 10 hours, refill reservoir to
Chief of Staff
level mark. Each 50 hours disassemble entire unit,
clean, re-oil and assemble.
OFFICIAL:
ROBERT M. JOYCE
Major General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-25B,
Operator
and
Organizational
maintenance
requirements for Motorized Roller.
TA220128
CARD 6 OF 6